my clutch lever is loose - Stunt Discussion

DirtyToes · 03-02-2007, 03:36 AM

i have the CRG lever installed on my bike....

if you're not familiar with them, they have 5 different setting for the stiffness of the clutch....i ALWAYS have it on 1 as it is the softest setting.

i went out for a ride last night and the clutch has become veeeeery loose for no apparant reason. setting 4 is now like setting 1 used to be. i looked on and around it a bit and it doesn't look like anyone has messed with it tho i could be wrong.

what could have caused this?

click9nine · 03-02-2007, 04:26 AM

my asv lever is doin this. its pissin me off. every red light i have to stop to tighten it. and my pull is hella inconsistent because of it

Suicidl · 03-02-2007, 04:38 AM

clutch cable is streched

DirtyToes · 03-02-2007, 04:49 AM

Quote:

Originally Posted by suicidl

clutch cable is streched

is it hard to replace.....i know how to replace the clutch part....but where does the other end go to? (f4i)

lamby · 03-02-2007, 05:11 AM

right side engine (clutch cover)

DirtyToes · 03-02-2007, 06:31 AM

Quote:

Originally Posted by lamby

right side engine (clutch cover)

too dark out but ill check it out tomorrow.

also, is this something common that happens when doing clutched wheelies?

bruno_z · 03-02-2007, 06:40 AM

my clutch is pretty much a living being...

it does what it wants and it loosens up all the time, have to adjust it every few min, the thread in the perch is dead so the adjuster screw can fall out very easy if far out and it's extremly hard to pull, and if its in you have to pull it all the way in just to start to disengage = not functional for stunting...it sucks big time, but im getting another one...

JOKER JOE · 03-02-2007, 06:29 PM

Their Shoul Be A Major Adjustment At The Other End Of The Cable Where The It Connects To The Clutch. Their Should Be Two Nuts One On Each Side Of The Bracket Adjust That Then Go Back To Your Clutch Perch And Readjust And You Should Fine.

zxcraig · 03-02-2007, 06:35 PM

dont know what to tell ya,,i've never has a prob like that

Wetley · 03-02-2007, 06:41 PM

do any of you oil your clutch cable ever for your daily driver, or do you just leave it be and hope it dont snap on ya? cuz my bikes my lot/street bike and my clutch lever is getting some slop it in slowly but surely

DirtyToes · 03-02-2007, 10:38 PM

Quote:

Originally Posted by westley

do any of you oil your clutch cable ever for your daily driver, or do you just leave it be and hope it dont snap on ya? cuz my bikes my lot/street bike and my clutch lever is getting some slop it in slowly but surely

shit i didnt even know you're supposed to lube it.

i messed with with clutch side of the cable a little bit this morning and its now alot better....i can pop wheelies again, but the clutch is somewhat harder than it used to be.

regarding the 2 nuts at the other end of the clutch...which way am i supposed to move em?

Danger_Dave · 03-03-2007, 06:58 AM

cable maintenance in general is something that goes neglected and its just as important as lubing and adjusting your chain

aw0n0 · 03-03-2007, 07:05 AM

Quote:

Originally Posted by Danger_Dave

cable maintenance in general is something that goes neglected and its just as important as lubing and adjusting your chain

not really, chains are way more expensive and harder to replace than clutch cables...
not to mention a chain snapping is usually way worse than a clutch cable snapping

DirtyToes · 03-05-2007, 05:38 AM

Quote:

Originally Posted by aw0n0

not really, chains are way more expensive and harder to replace than clutch cables...
not to mention a chain snapping is usually way worse than a clutch cable snapping

speaking of chains....this guys chain just locked and snapped today...and on the freeway! this was followed by a eighteen wheeler knocking him outta the way. the guy is in critical condition.

going back to my cluch cable...i think that tho its not AS important as chain, is still pretty fuckin importat....i mean, i wouldnt want my clutch engaging and disengaging by itself all the time...especially if i'm up on a wheelie.

p.s. its been almost 2 days now, my clutch is still good. havnt adjugest it since then, and i rode alot over the weekend.

Wetley · 03-06-2007, 04:24 PM

Quote:

Originally Posted by aw0n0

not really, chains are way more expensive and harder to replace than clutch cables...
not to mention a chain snapping is usually way worse than a clutch cable snapping

i snapped my chain in a sit down...it was pretty messy...

...from then on, i always make sure my chain is clean, lubed, and adjusted properly

03-02-2007, 03:36 AM	#1
DirtyToes Registered User Join Date: Jan 2007 Location: LA, CA, USA Age: Bike: 2001 f4i Gender: Male Posts: 2,168	my clutch lever is loose i have the CRG lever installed on my bike.... if you're not familiar with them, they have 5 different setting for the stiffness of the clutch....i ALWAYS have it on 1 as it is the softest setting. i went out for a ride last night and the clutch has become veeeeery loose for no apparant reason. setting 4 is now like setting 1 used to be. i looked on and around it a bit and it doesn't look like anyone has messed with it tho i could be wrong. what could have caused this?

03-02-2007, 04:26 AM	#2
click9nine Registered User Join Date: Jul 2006 Location: jamaica Age: Bike: dfd Gender: Male Posts: 46	Re: my clutch lever is loose my asv lever is doin this. its pissin me off. every red light i have to stop to tighten it. and my pull is hella inconsistent because of it

03-02-2007, 04:38 AM	#3
Suicidl WWW.Sickinnovations.com Join Date: May 2004 Location: O-Town Age: Bike: 636 Gender: Male Posts: 14,065	Re: my clutch lever is loose clutch cable is streched

03-02-2007, 05:11 AM	#5
lamby Registered User Join Date: Aug 2006 Location: Queens, NY Age: Bike: 05 crf50 Gender: Male Posts: 743	Re: my clutch lever is loose right side engine (clutch cover)

03-02-2007, 06:40 AM	#7
bruno_z Registered User Join Date: Nov 2003 Location: Croatia (Europe) Age: Bike: 919 Gender: Male Posts: 2,130	Re: my clutch lever is loose my clutch is pretty much a living being... it does what it wants and it loosens up all the time, have to adjust it every few min, the thread in the perch is dead so the adjuster screw can fall out very easy if far out and it's extremly hard to pull, and if its in you have to pull it all the way in just to start to disengage = not functional for stunting...it sucks big time, but im getting another one... __________________ Never drive faster than your guardian angel can fly!

03-02-2007, 06:29 PM	#8
JOKER JOE Registered User Join Date: Sep 2006 Location: SANTA MARIA CA Age: 29 Bike: 954 Gender: Male Posts: 70	Re: my clutch lever is loose Their Shoul Be A Major Adjustment At The Other End Of The Cable Where The It Connects To The Clutch. Their Should Be Two Nuts One On Each Side Of The Bracket Adjust That Then Go Back To Your Clutch Perch And Readjust And You Should Fine.

03-02-2007, 06:35 PM	#9
zxcraig Registered User Join Date: Feb 2006 Location: D-PORT,IOWA Age: 32 Bike: 08 zx6, 03 zx6rr Gender: Male Posts: 1,053	Re: my clutch lever is loose dont know what to tell ya,,i've never has a prob like that

03-02-2007, 06:41 PM	#10
Wetley Registered User Join Date: Jul 2006 Location: Newport Beach, Pomona Age: Bike: 98 900RR Gender: Male Posts: 817	Re: my clutch lever is loose do any of you oil your clutch cable ever for your daily driver, or do you just leave it be and hope it dont snap on ya? cuz my bikes my lot/street bike and my clutch lever is getting some slop it in slowly but surely

03-03-2007, 06:58 AM	#12
Danger_Dave Registered User Join Date: Oct 2005 Location: stuntshine state Age: 26 Bike: F4i, Crf88, Gixxer 750 ressurection Gender: Male Posts: 2,286	Re: my clutch lever is loose cable maintenance in general is something that goes neglected and its just as important as lubing and adjusting your chain

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
Clutch lever	Tiretrauma	Stunt Discussion	12	12-15-2006 12:23 PM
Can't get the nut loose on the center clutch????	mr_payne2003	Service, Repair, and Maintenance	7	07-03-2006 11:58 PM
clutch lever	cutter	Service, Repair, and Maintenance	10	11-16-2005 02:13 PM
Loose clutch cord??	Hondaboy911	Service, Repair, and Maintenance	4	08-27-2005 07:12 PM
clutch lever........?	GSE Lasker	GodSpeed Extreme - GSE	4	03-16-2003 07:20 PM